Where Is The Egr Valve On A 2002 Ford Focus? Open the hood of the Focus. Notice the EGR valve, which is a circular valve located on the engine intake manifold. It is secured in place by bolts.
Where is the EGR valve located on a 2002? left side
The EGR valve is located on the left side on the rear of the engine. Since the engine sits sideways in the vehicle it will be right about in the middle of the engine compartment towards the front of the engine. It unbolts with two bolts. You should do this when the engine is cold.
Where is a EGR valve located? intake manifold
The EGR valve is usually located near or attached to the intake manifold, with a tube running to the exhaust manifold. There should also be a vacuum or electrical connector (or both) running to the valve which will need to be detached.
How do I know if my EGR valve is bad? What are the symptoms of a failing EGR valve
Where Is The Egr Valve On A 2002 Ford Focus? – Related Questions
How much does it cost to replace a EGR valve on a Ford Focus?
The average cost for a Ford Focus EGR valve replacement is between $193 and $298. Labor costs are estimated between $84 and $107 while parts are priced between $109 and $191.
How do you change a EGR valve on a 2002 Ford Focus?
How to Replace an EGR Valve in a 2002 Ford Focus
Allow the Ford Focus engine to cool down.
Open the hood of the Focus.
Use a socket wrench and remove the bolts holding the EGR valve in place.
Install the new valve by placing it onto the valve mount on the engine intake manifold.
Can I replace my EGR valve myself?
Although it’s possible to complete an EGR valve replacement yourself, due to the need to access the engine chamber, it’s not recommended unless you’re an experienced mechanic.
Can you drive a car with a faulty EGR valve?
Can I drive with a bad EGR valve
Can I disconnect my EGR valve?
No, unplugging it will not stop the EGR cooler from failingthe hot gases will still be there to melt the solder and cause a leak. You’re not dreaming unplugging the EGR does give you better throttle response.
Will a bad EGR valve throw a code?
Question: If I have a bad EGR valve, will it throw a code for a misfire in cylinder number 2
Is it better to clean or replace EGR valve?
If your car is running fine at idle and you don’t have a check engine light, there’s no need to replace or clean an EGR valve. Some shops recommend periodic cleaning. If the valve is stuck open due to carbon, rather than the money to clean it, you’re better off having the shop install a new EGR valve.
How long does it take to replace the EGR valve?
How long does an EGR valve replacement take
Where is the EGR valve located on a 2004 Ford Focus?
The EGR valve is located in the engine compartment (underneath the hood).
What are the symptoms of a bad EGR pressure sensor?
As with any EGR issue, the most common symptoms noticed when the exhaust gas recirculation pressure feedback sensor fails are rough idling, hesitation accelerating from a stop, lack of engine power, misfires, and, of course, illumination of the dreaded check engine light.
How much does it cost to replace EGR sensor?
The average cost for EGR valve position sensor replacement is between $96 and $107. Labor costs are estimated between $41 and $52 while parts are priced at $55. This range does not include taxes and fees, and does not factor in your specific vehicle or unique location.
How hard is it to replace EGR valve?
In most models, replacing an exhaust gas recirculation (EGR) valve is not difficult. You can do it in your garage in about an hour or two, depending on your particular system, using some common tools and a good solvent like carburetor cleaner.
What can I soak my EGR valve in to clean it?
What can I soak my EGR valve in to clean it
Is it worth cleaning EGR valve?
Cleaning your EGR valve will solve your car’s engine performance issues related to any clogging or system passages problem with the valve. Even more importantly, it’ll prevent serious engine damage and expensive repairs. In severe cases, this develops into violent detonations that will seriously damage your engine.
How long can you drive with bad EGR?
An EGR valve may last 100,000 miles if the part is designed well, or it may last only 30,000 miles.
Will a bad EGR valve make a car not start?
The exhaust gas recirculation (EGR) valve introduces a measured amount of exhaust gases; into the intake manifold to get re-burned.
But, the valve can fail and stick either open or closed.
When the valve sticks open it may prevent your engine from starting.
What causes EGR valve failure?
The failure of the EGR valve on the vehicle is not out of the ordinary, as this issue can arise on most modern diesel engines.
The failures are usually caused by a build-up of deposits in the EGR valve over a period of time that causes them to stick.
